Pilot Debrief

EXTRA FLUGZEUGBAU GMBH EA 300/L near Pell City, AL — 2021-01-13

Final reportERA21LA107
Sign in to save
Date
2021-01-13
Location
Pell City, AL, USA
Airport
PLR
Aircraft
EXTRA FLUGZEUGBAU GMBH EA 300/L
Registration
N771JP
Category
Airplane
Highest injury
None
Fatalities
0
Phase of flight
Approach

Probable cause

The pilot's mismanagement of the fuel supply, which resulted in fuel starvation. Contributing to the accident was the pilot’s failure to follow the manufacturer’s engine restart procedures after a total loss of engine power and his incomplete preflight inspection.

NTSB narrative

The pilot departed on a short local flight with 14 gallons of fuel in the main wing tanks and 12 gallons in the center tank. About 1,500 ft above ground level, the airplane experienced a total loss of engine power. The pilot initially attempted to restart the engine using fuel from the center tank in accordance with the Extra 300L Pilot’s Operating Handbook, which stated that engine restart in flight should be attempted on the center fuel tank. However, when the engine did not restart, he switched back to the main tanks but was still unable to restart the engine. The pilot made a forced landing, during which the airplane sustained substantial damage. A detailed examination of the engine revealed no anomalies. The engine was rotated manually, and thumb compression was obtained on all cylinders. A small amount of fuel was found at the inlet of the engine-driven fuel pump and the inlet to the fuel servo. The fuel inlet screen was removed from the fuel injector and found to be clean and unobstructed. About two to three drops of fuel were found in the line connecting the fuel injector to the fuel flow gauge. About two to three drops of fuel were also found in the line from the fuel flow gauge to the fuel manifold. After fuel was added to the center tank, the engine started and ran smoothly and continuously. The pilot stated that, before takeoff, he checked the fuel quantity in the left fuel tank but not the right fuel tank. The higher quantity of fuel toward the fuel pump compared with the quantity leading to the fuel manifold suggested that the lines were empty of fuel before the pilot switched to the center tank fuel supply, partially allowing some fuel back into the system but not enough to reach the combustion chambers before the pilot switched back to the main tanks. Thus, if the pilot had continued the restart procedure using the center fuel tank, as stated in the Pilots’ Operating Handbook, the engine would likely have regained power. Instead, fuel starvation occurred. The pilot provided information indicating that the accident could have been the result of the Extra EA300L fuel pickup tubes being rotated upward during maintenance, which would have prevented usable fuel from entering the fuel line. However, only trace amounts of fuel were found in the wing, and no maintenance records were provided to indicate when the fuel pickup tubes could have been incorrectly positioned.

Analysis

Primary failure mode
Fuel management
First missed decision gate
Pilot should have checked fuel in both wing tanks before departure.

NTSB coding

Evidence available

  • FDR / data
  • Photos
  • 12 docket documents
View NTSB final reportView NTSB docket

Docket documents12

Related mishaps