BOAM RANS S-6S near Roberts, ID — 2010-09-18

Probable cause

A loss of engine power due to the detachment of the left carburetor from the engine inlet manifold. Contributing to the accident was the pilot's failure to address a known engine vibration.

NTSB narrative

The pilot, who was also the airplane's owner, reported that the engine of the experimental amateur-built airplane experienced a partial loss of power while turning onto the crosswind leg of the traffic pattern after the initial takeoff climb. The pilot initiated a return to the runway, during which time the engine lost all power. The pilot unsuccessfully attempted to restart the engine and subsequently performed an off-airport landing. The airplane's right main landing gear collapsed during the landing roll, resulting in substantial damage to the airframe. Examination of the engine revealed that the left carburetor was detached from the engine inlet manifold. The impact trajectory, coupled with a lack of witness marks indicating the carburetor had struck any part of the airplane, make it most likely that the carburetor detached in flight. The owner/pilot reported that he had experienced excessive engine vibration and "kickback" during prior startups. He had considered a number of remedial measures to rectify the problem, but had not performed any of these measures prior to the accident flight. He additionally reported that he could have reduced the likelihood of the carburetor separating by more thoroughly examining the tension of its mounting hardware.

Analysis

Primary failure mode

Engine power loss

First missed decision gate

Inspecting carburetor mounting clamp tension could have prevented power loss.

NTSB coding

• Loss of engine power (partial) · Takeoff
• Loss of Thrust on Takeoff
• Maintenance

Evidence available

• Photos
• 7 docket documents

Docket documents7

• Pilot/Operator Aircraft Accident Report, NTSB Form 6120.1form
• Maintenance Logbook Excerptsother
• Soft Start Module Description, Retrieved from http://www.bullyhawk.com/ssm.htm, on March 6 2011other
• Photograph 1: Firewall Damage - FAA Photographphotos
• Photograph 2: Left Carburetor - FAA Photographphotos
• FAA Inspector's Reportreport
• Mechanic's Reportreport

Related mishaps

• CESSNA 172I

  2024-11-14 · Los Angeles, CA

• CIRRUS DESIGN CORP SR22T

  2024-06-23 · Boerne, TX

• CESSNA 172G

  2024-05-16 · Lakeport, CA

• KJELSRUD GARY KITFOX

  2024-05-10 · Powell, WY

• BEECH B24R

  2024-04-22 · Lumberton Township, NJ

• CESSNA 177RG

  2023-10-01 · Lake Placid, NY · 2 fatalities