Pilot Debrief

PIPER PA 32-300 near Redlands, CA — 2015-05-09

Final reportWPR15LA157
Sign in to save
Date
2015-05-09
Location
Redlands, CA, USA
Airport
REI
Aircraft
PIPER PA 32-300
Registration
N4124R
Category
Airplane
Highest injury
None
Fatalities
0
Phase of flight
Initial climb

Probable cause

The partial loss of engine power during takeoff due to oil starvation.

NTSB narrative

The commercial pilot reported that, about 30 seconds after takeoff, while the airplane was 250 ft above ground level, the engine began to emit an unusual sound, and he felt a vibration. He chose to land immediately and, due to obstacles ahead, he turned back toward the airport. He completed a steep turn and descended rapidly with the engine producing only partial power. Unable to maintain altitude, the airplane subsequently touched down hard on the runway. The pilot swerved to avoid oncoming traffic, which resulted in the right wing impacting a runway sign. A postaccident examination of the engine revealed that there was a large hole on the top of the crankcase. Two connecting rods were separated from the crankshaft and exhibited mechanical and thermal damage, consistent with oil starvation. Oil streaks were found near the taxiway and run-up area, consistent with the airplane extruding oil before takeoff. When compressed air was directed into the oil cooler, air expelled from a small gap between mating brazed plates, indicating that oil could have extruded from that location.

Analysis

Primary failure mode
Engine power loss
First missed decision gate
Pilot could have aborted takeoff upon hearing unusual engine noise.

NTSB coding

Evidence available

  • 3 docket documents
View NTSB final reportView NTSB docket

Docket documents3

Related mishaps