HILLER UH 12A near Griffith, IN — 2017-09-11

Probable cause

The loss of tail rotor thrust due to a failed tail rotor driveshaft, which resulted in a loss of tail rotor control and a hard landing.

NTSB narrative

The flight instructor was providing dual flight instruction to a student pilot in the helicopter. About 10 minutes into the flight, while in a 3-5 ft hover, the student began to lose helicopter control and the helicopter began to spin to the right. Because the student could not regain control, the instructor took the controls, but the helicopter did not respond to cyclic inputs and left pedal input. At this point, the instructor assumed there was a loss of thrust from the tail rotor. He rolled the throttle off, and the helicopter settled to the ground and landed hard. After the landing, the instructor observed that the tail rotor and tail rotor driveshaft were not spinning and heard a grinding noise near the connection of the transmission output shaft and the tail rotor driveshaft. The instructor found that the tail rotor guard had broken off the helicopter and was about 20 ft away. The instructor could not recall if or when the tail rotor guard struck the ground. Examination of the helicopter revealed that the tail rotor driveshaft had failed near the output shaft of the tail rotor drive assembly. Substantial damage was incurred to the tail rotor and tailboom. Maintenance records were not available. Because neither the student nor the instructor could regain helicopter control, it is likely that the tail rotor driveshaft failed in flight, which led to the loss of tail rotor thrust and subsequent loss of tail rotor control.

Analysis

Primary failure mode

Mechanical failure

First missed decision gate

CFI could have aborted the flight before loss of control occurred.

NTSB coding

• Flight control sys malf/fail · Maneuvering

Evidence available

• Photos
• 5 docket documents

Docket documents5

• Pilot/Operator Aircraft Accident Report, NTSB Form 6120.1form
• IHST Helicopter Accident/Incident Supplemental Checklistother
• Memorandum for the Record - FAA Inspector Phone Conversationother
• Schematic Diagrams of Tail Rotor Drive Componentsother
• Photo Arrayphotos

Related mishaps

• CESSNA R172E

  2024-07-06 · Hillrose, CO

• PIPER PA-34-200

  2023-05-03 · Coldspring, TX

• PIPER PA-14

  2021-07-23 · Anchorage, AK

• SOPWITH Type 9400

  2020-07-03 · Van Alstyne, TX

• Autogyro Cavalon

  2018-10-30 · Sebring, FL · 2 fatalities

• Beech 35

  2018-09-22 · Georgetown, SC