Pilot Debrief

JOHNSTON DOUGLAS S SAFARI near McVeytown, PA — 2012-09-01

Final reportERA12LA541
Sign in to save
Date
2012-09-01
Location
McVeytown, PA, USA
Aircraft
JOHNSTON DOUGLAS S SAFARI
Registration
N70415
Category
Helicopter
Highest injury
Fatal
Fatalities
1
Phase of flight
Maneuvering

Probable cause

The pilot's lack of proficiency and certification, which resulted in his failure to enter an autorotation when the engine lost power. Contributing to the accident was the pilot’s inadequate fuel planning, which resulted in fuel exhaustion and a subsequent loss of engine power.

NTSB narrative

A witness who spoke with the pilot before the flight reported that the pilot had checked the fuel before departure and intended to "make a couple of laps" before proceeding to a local airport to purchase more fuel. Another witness observed the helicopter perform two 180-degree turns before it descended and impacted the ground. Examination of the accident site confirmed a vertical impact, and the helicopter damage was consistent with low or minimal rotor speed at the time of impact. Inspection of the fuel system revealed no fuel in the right fuel tank and about 2 pints of fuel in the left fuel tank. No contamination was observed in the fuel on board, and no obstructions were observed in the fuel system. The experimental amateur-built helicopter was constructed from a kit and received its airworthiness certificate in 2003. The pilot purchased the helicopter about 4 months before the accident through the kit manufacturing company, which was brokering the sale of the helicopter for the builder’s estate. The pilot did not hold a pilot certificate and did not register the helicopter with the FAA. Examination of the pilot's logbook revealed that about 2 years before the accident, he had received 3.2 hours of helicopter instruction. Interviews revealed that when the pilot acquired the helicopter, he flew an additional 15 hours with the owner of the helicopter kit manufacturing company (in the accident helicopter and another company helicopter). However, these flights were limited to hover practice. It is likely that while the pilot was maneuvering the helicopter at a low altitude, it experienced a loss of engine power due to fuel exhaustion. At this point, the pilot needed to immediately enter an autorotation. However, given the pilot’s limited flight training and his lack of pilot certification (he would have had to demonstrate an autorotation in order to become a certificated helicopter pilot), he almost certainly was not proficient in performing autorotations. The helicopter’s vertical impact with low rotor rpm is consistent with the pilot failing to make the control inputs necessary to enter an autorotation.

Analysis

Primary failure mode
Fuel management
First missed decision gate
Pilot should have ensured adequate fuel before attempting flight.

NTSB coding

Evidence available

  • Photos
  • 18 docket documents
View NTSB final reportView NTSB docket

Docket documents18

Related mishaps