ISRAEL AIRCRAFT INDUSTRIES 1124A near Huntsville, AL — 2014-06-18
- Date
- 2014-06-18
- Location
- Huntsville, AL, USA
- Airport
- HSV
- Aircraft
- ISRAEL AIRCRAFT INDUSTRIES 1124A
- Registration
- N793BG
- Category
- Airplane
- Highest injury
- Fatal
- Fatalities
- 3
- Phase of flight
- Takeoff roll
Probable cause
The flight crew's inability to maintain airplane control during initial climb following deployment of the right thrust reverser for reasons that could not be determined because postaccident examination of the airframe and engine thrust reverser system did not reveal any anomalies. Contributing to the accident was the excessive thrust from the right engine with the thrust reverser deployed for reasons that could not be determined during postaccident examinations and testing.
Contributing factors
Contributing to the accident was the excessive thrust from the right engine with the thrust reverser deployed for reasons that could not be determined during postaccident examinations and testing.
NTSB narrative
A pilot proficiency examiner (PPE) was using the airplane to conduct a pilot-in-command (PIC) proficiency check for two company pilots. Before the accident flight, one of the two company pilots on board received a PIC proficiency check, which terminated with a full-stop landing and reverse thrust application; no discrepancies with either thrust reverser were discussed by either flight crewmember. The pilot being examined then left the cockpit, and the accident pilot positioned himself in the left front seat while the PPE remained in the right front seat. The flight crew then taxied to the approach end of the runway to begin another flight. Data from the enhanced ground proximity system (EGPWS) revealed that, the flight began the takeoff roll with the flaps retracted, the thrust reversers armed, and both engines stabilized at 96 percent N2. About 2 seconds later, the cockpit voice recorder (CVR) recorded the "V1" call while on the airplane was on the runway; acoustic analysis indicated that the N2 speed of one engine, likely the right, decreased; the N2 speed of the other engine remained constant. This decrease in N2 speed was consistent with the PPE retarding right engine thrust to flight idle with the intent of simulating an engine failure. The takeoff continued, and, while the airplane was in a wings-level climb at an airspeed of 148 knots about 18 ft radar altitude, the CVR recorded the pilot command that the landing gear be retracted. The landing gear remained extended, and, about 1 second after the command to retract the landing gear, or about 3 seconds after becoming airborne, while about 33 ft above the runway and at the highest recorded airspeed of 149 knots, the CVR recorded the beginning of a rattling sound, which was consistent with the deployment of the right thrust reverser, and it continued to the end of the recording. About 1.5 seconds after the rattling sound began, the CVR recorded the PPE asking, "…what happened," which indicates that the deployment was likely not annunciated in the cockpit. The right engine N2 speed continued to gradually decrease, and the airplane rolled slightly left, back to a wings-level position. The airplane continued climbing with the landing gear extended as pitch changes continued to occur. During this time, the flight crew exchanged comments about their lack of understanding about what was occurring. While flying 10 knots above V2 speed with the left engine N2 speed remaining steady and the right engine N2 speed decreasing at a slightly greater rate than previously, the airplane began a right roll with a corresponding steady decrease in airspeed from about 144 knots. About 9 seconds after the original call to retract the landing gear, the CVR recorded the PPE requesting that the landing gear be retracted, which occurred 1 second later. The airplane then continued in the right turn with the airspeed steadily decreasing, and about 11 seconds after the PPE asked "…what happened", the EGPWS sounded a bank angle alert. At that time, the airplane was in a right roll of about 30 degrees, and the airspeed was about 132 knots. The right roll continued to a maximum value of about 39 degrees, which was the last valid bank angle value recorded. The airplane impacted the ground off the right side of the runway in a nose- and right-wing-low attitude. The landing gear and flaps were retracted, and there was no evidence of preimpact failure or malfunction of the flight controls for roll, pitch, and yaw; nor was there any evidence of a mechanical failure or malfunction of either engine. A definitive reason for the deployment of the right thrust reverser could not be determined. No previous instances of inadvertent in-flight thrust reverser deployment were documented by the operator of the accident airplane or by the airframe manufacturer for the accident airplane make and model. Certification flight testing of an airplane with the same thrust reverser system determined that the airplane remained controllable with the right thrust reverser deployed and throttle retarder system functioning. The flight testing also included application of a momentary, peak burst of right engine thrust, again with no controllability issues noted. It was also noted that with the installed throttle retarder system, in the event of inadvertent thrust reverser deployment, that the engine's thrust should have been reduced to idle within 4 to 8 seconds. Acoustic analysis of the accident flight indicated that the lowest recorded N2 rpm value was about 84 percent and that the reduction in rpm occurred over a period of about 8.5 seconds, after the right thrust reverser deployed. No determination could be made as to why the throttle retarder system did not reduce the right engine thrust to flight idle as designed. Additionally, no determination could be made as to why the flight crew was not able to maintain directional control of the airplane following deployment of the right thrust reverser. Although the PPE had severe coronary artery disease, which placed him at risk for an acute coronary event that would cause symptoms like chest pain, shortness of breath, or sudden unconsciousness, the CVR recorded no evidence of impairment. Neither the heart disease nor the medications he was taking to treat it would have impaired his judgement or physical functioning. Therefore, it is unlikely any medical condition or substance contributed to the PPE's actions. Additionally, there was no evidence that any medical condition would have impaired judgement or physical functioning of the pilot being examined.
Analysis
- Primary failure mode
- Automation / mode confusion
- First missed decision gate
- Properly configure thrust reversers before takeoff to prevent deployment.
NTSB coding
Evidence available
- CVR
- ATC audio
- Video
- Photos
- 36 docket documents
Docket documents36
- ATC 3 - Chronological Summary of Communications and Transcription of Communicationsatc
- ATC 3 – Daily Record of Facility Operation for Huntsville Air Traffic Control Toweratc
- ATC 3 – Flight Progress Stripatc
- ATC 3 – Personnel Statementsatc
- Cockpit Voice Recorder - Group Chairman's Factual Reportcvr
- Enhanced Ground Proximity Warning System/Cockpit Voice Recorder Overlay - Specialist's Study Reportcvr
- FAA 8710-1 Forms for FAA Authorized Pilot Proficiency Examiner (FAA PPE)form
- Pilot Proficiency Examiner Informationform
- Pilot/Operator Aircraft Accident Report, NTSB Form 6120.1form
- Release of Aircraft Wreckage, NTSB Form 6120.15, and Evidence Control Pagesform
- Statement of Party Representatives to NTSB Investigationinterview
- Witness Statementsinterview
- Enhanced Ground Proximity Attachment 1 – Tabular Data (CSV)other
- Excerpt from Airplane Flight Manual Pertaining to Inadvertent Thrust Reverser Delpoymentother
- Excerpt from Computerized Aircraft Maintenance Systemsother
- Excerpts from Airplane Type Certificate Data Sheetother
- Excerpts from Available Maintenance Records Documenting Last 800 Hour Inspectionother
- Excerpts from Discrepancy List From Last 200 and 400 Hour Inspectionsother
- Excerpts from Maintenance Manual Pertaining to Throttle Retarder Systemother
- Excerpts from Maintenance Manual Pertaining to Thrust Reverser System Inspection and Testingother
- Excerpts from Repair Station for Last 200 and 400 Hour Inspections Pertaining to Thrust Reverser Inspectionsother
- Excerpts of FAA Regulations in Effect at Time of U.S. Certificationother
- FAA Record of Conversationsother
- Honeywell Test Cell Engine N1 and N2 Deceleration Test Plotother
- NTSB Request to Israel Aircraft Industries (IAI) for Flap and Trim Positionsother
- Record of NTSB Conversationsother
- Response from Israel Aircraft Industries (IAI) with Flap and Trim Positionsother
- Investigative Photographsphotos
- FAA Toxicology Reportsreport
- Flight Test Report from IAI Concerning Thrust Reverser Deploymentreport
- NTSB Computed Tomography Specialist's Factual Reportreport
- NTSB Vehicle Recorder Division Enhanced Ground Proximity Warning System Specialist’s Factual Reportreport
- Powerplants Factual Reportreport
- Sound Spectrum - Specialist's Study Reportreport
- Weather Reports and Recordsreport
- NTSB Vehicle Recorder Division Security Video – Specialist’s Factual Reportvideo
Related mishaps
- ROBINSON HELICOPTER R44
2026-07-20 · Emerson, IA
- BELL 47G-2
2026-06-01 · Mettler, CA
- VANS RV4
2026-05-13 · Conroe, TX
- CESSNA 172
2026-01-07 · San Marcos, TX
- ELA ELA10
2025-12-23 · Morris, IL
- MARK O TREIDEL American Ranger AR-1
2025-12-16 · Denver, CO